Volkswagen Emissions Fix May Not Last Long Thanks to Aftermarket Tuners

Bozi Tatarevic
by Bozi Tatarevic

Many in the Volkswagen diesel community are fanatical about their fuel economy and are understandably angry that a fix for the current emissions scanda l may see them lose fuel economy in order to lower NOx output. The aftermarket community has provided modifications for the DPF and Adblue systems in the past, meaning there’s good chance they’ll provide parts and tuning to revert any changes Volkswagen may implement on the affected models.

There are a number of paths which Volkswagen may take that range from an ECM patch to new SCR hardware that could be installed.

The non-SCR models may get a software patch that would alter the injection timing and increase the regen cycle. This would cause the NOx emissions to go down but would take fuel economy and power along with it. It could also cause carbon build-up on the pistons and catalyst which could lead to increased maintenance costs for the owners.

The other path for the non-SCR cars is implementation of an SCR system, but that may not be cost effective due to the parts cost and labor required. I speculate that the SCR cars could receive an ECM patch that would increase regen cycles along with increasing the amount of Adblue that would be dosed. This would work out better than any fix for the non-SCR cars but would still result in higher Adblue costs.

Owners may look to the aftermarket to defeat these fixes so that they can keep their power and fuel economy.

The aftermarket community has released modifications for the DPF and Adblue SCR systems long before there was any talk of reduced power and economy coming from a potential fix for the emissions scandal. They looked to gain more power and better fuel economy by modifying or deleting the DPF system. Aftermarket tuners such as Rawtek and Malone Tuning produce kits for DPF models which replaces the DPF and EGR systems with stainless steel exhaust piping and tunes the ECM for better fuel economy and performance. They mark these systems as off-road only as they violate federal emissions laws. Rawtek also produces a kit for the Passat that deletes the Adblue SCR system along with the DPF and EGR and also advertises gains in power and fuel economy.

The tuners responded to the VW stop-gap recall which was released a few months ago, Volkswagen’s attempt to curtail this emissions scandal. The tuners let the owners know that they can revert the recall programming and reflash their previous tune for a minimal cost. The current versions of the ECM hardware and firmware may become an avenue for re-flashing if there is demand from owners after the recall fix as it would allow their vehicles to be reverted back to the programming they had when they purchased the vehicle.

In the end, unless Volkswagen implements some sort of encryption or lock on the fix, owners looking for power or economy will look to the aftermarket and revert back any emissions improvements that are made.

[Image Credit: Tony Hisgett/ Flickr/ CC BY 2.0]

Bozi Tatarevic
Bozi Tatarevic

More by Bozi Tatarevic

Comments
Join the conversation
2 of 52 comments
  • Cabriolet Cabriolet on Sep 22, 2015

    I wonder who the next car company will be doing the same thing to pass the EPA testing. How many states have inspection rules? New York state only plugs into the computer and if no codes appear you are good to go. Even if the air bag light is on you are good to go. Note to EAF you have a problem. Have you ever owned a Subaru?

  • HotPotato HotPotato on Sep 23, 2015

    If VW and EPA attempt to address VW's violation by applying a software patch to the guilty cars, it won't go well. Owners will sue VW for the hits to performance, MPG, reliability, and resale value. Owners will curse EPA for party-pooping, and possibly override the patch in the aftermarket anyway. So it would be in the interest of both VW and EPA, strangely enough, to leave the guilty cars alone. Instead: 1. Figure out how much additional NOx the cars will produce over their expected lifetimes. 2. Figure out how much money it would take to reduce that much NOx from other sources. You could use incentives: cash to utilities to convert coal-fired power plants to gas, cash to consumers to buy battery electric vehicles (BEVs) in states with clean energy grids. You could use direct action: install solar panels atop government buildings. You could use mandates: require VW to sell X amount of BEVs, and leave it up to them to figure out how. In designing the plan, include administrative costs, and focus on geographical areas where NOx reductions will help the most due to smog levels or acid rain or whatnot. 3. Calculate substantial punitive damages. 4. Add the figures from #2 and #3. That's your fine. Suspend part of the punitive damages so long as compliance with the agreement is maintained. 4. Implement #2.

  • Peeryog Everytime I see one I am reminded of the current Santa Fe. And vice versa.
  • Original Guy I watched that Moscow parade thing. (With the Cyrillic captions because my Russian is a little rough.) I won't give the whole thing away, but it started off with a couple of dudes riding around in stupid useless convertibles, standing up like Hitler, who I'm pretty sure was an actual Nazi. They drove around in circles and kept stopping to ask if anyone had seen all the missing military equipment, and all the guys kept moaning back, that no, they hadn't, ask the next section of guys.They looked around for someone shorter and sicker-looking than Putin but they were unsuccessful so they let him speak.The North Korean military was there, I guess the invasion has begun. The North Korean guys were skinny but their rifles were nicely polished, I guess they have plenty of time on their hands between meals.Some of the Russian military guys carried little white flags, I assume they keep those handy in case they run across any U.S. Marines.
  • Marc J Rauch EBFlexing on ur mom - Ethanol is compatible with more types of rubber, plastic, and metal than gasoline and aromatics. This means that ethanol is less corrosive. The bottom line is that long before ethanol could have any damaging effect on any engine component, gasoline and aromatics would have already damaged the components. And the addition of ethanol doesn't exacerbate the problems caused by gasoline and aromatics; it actually helps mitigate them.
  • Original Guy Today I learned that a reverse brake bleeder (and a long borescope) can be helpful if you are autistic and don't have any friends and no one wants to work with you to bleed your brakes. Also it is quick, once you figure out the process.When Canada assembled my truck back in circa 1995, they apparently used a different clip to attach the brake pedal (and switch) to the brake booster than what is technically called for. It is tough to realize this when the spring steel clip flies off to who knows where. Of course I ordered the wrong clip trying to match the style that I saw buried up in the dash before it flew away. My truck now has the 'correct' clip, everyone can relax.I ordered some more brake fluid (DOT 3, nothing fancy) but it turns out I still have two fresh bottles (my shelves aren't empty, I just have too many shelves).Went to install my fancy new Optima YellowTop battery and it turns out I need a new side post terminal bolt. (Yet another order placed, bring on THE TARIFFS.) It would be a shame to strip out the threads on a nice new battery, no?Good news: The longer it takes me to get my truck started again, the more I save on fuel. 😁
  • Normie Weekends here would be a great time for everyone to join in praise of dog dish hubcaps on body-color matched steelies!
Next